Generac 9600-3 Manuale Utente Scaricare il pdf (Pagina 18)

TROUBLESHOOTING

PROBLEM

POSSIBLE CAUSE(S)

REMEDY

Engine won’t crank

1. 15 amp fuse blown.

2. Loose, corroded or defective battery

cable(s).

3. Battery is discharged or defective.

4. Defective starter contactor.

5. Defective starter motor.

6. Defective controi relay (CR1).

1. Replace blovm fuse.

2. Tighten, clean or replace, as

necessary.

3. Recharge or replace battery.

4. Replace starter contactor.

5. Replace starter motor.

6. Replace control relay.

Engine cranks, won't start

1. Out of fuel.

2. Fuel shutoff valve is closed.

3. Fuel pump not operating.

4. Automatic choke not operating

properly.

5. Engine is flooded.

6. Fuel filter is clogged.

7. Defective Controller Circuit Board

8. Engine spark plugs defective.

9. Bad ignition magneto on engine.

10. Bad carburetor.

11. Dirty air cleaner.

1. Refill fuel tank.

2. Open fuel shutoff valve(s).

3. Repair or replace pump.

4. Repair, replace or acyust.

5. Wait 5-10 minutes: try again.

6. Replade filter if clogged.

7. Replace bad circuit board.

8. Clean, regap or replace as needed.

9. Replace if defective.

10. Adjust, repair or replace.

11. Clean or replace as needed.

Engine starts hard,

run rough.

1. Dirty engine air cleaner.

2. Automatic choke is sticking.

3. Defective spark plugs.

4. Defective ignition magneto.

1. Clean or replace as needed.

2. Free choke linkage as needed.

3. Clean, regap or replace.

4. Replace it if defective.

Engine starts, then

shuts down.

1. Engine oil level is low

2. Bad control relay (CR1).

3. Bad low oil pressure switch.

4. Bad control relay (CR2).

1. Add oil as needed.

2. Replace if bad (CR1).

3. Replace, if bad.

4. Replace bad relay (CR2).

No AC output voltage 1. Main breakers open.

2. Transfer switch (if so equipped)

is set to wrong position.

3. Failure in vehicle electrical system.

4. Generator component failure.

1. Cloase main breakers.

2. Reset transfer switch.

3. See vehicle manual.

4. Contact an authorized service facility.

-16-

1 2 ... 13 14 15 16 17 18 19 20 21 22 23 ... 31 32

Commenti su questo manuale

Nessun commento